Canning Pumpkin Butter, Pumpkin Puree or Pumpkin Pie Filling at Home?
The USDA's safety recommendations against canning pumpkin butter and other pumpkin purees at home.
Can I can pumpkin butter or pumpkin puree at home? I get asked this question a lot! You may can pumpkin butter or puree in a cooked, cubed form; just not as a puree or ready-pumpkin pie filling. (see this page for instructions about how to can it in cubed form). Of course, you can freeze it, too, in cubed or puree or ready filling form (see this page for those instructions). And while I do have a recipe for canning pumpkin butter, I still keep the jars in the back of the fridge until I use them. Here's the reason!
According to The National Center for Home Food Preservation (a land-grant university consortium sponsored by the USDA, and considered to be the leading authorities on food safety science and food preservation research) . In 1989, the USDA's Extension Service revised recommendations and published the Complete Guide to Home Canning" (and I am quoting them here):
“Home canning is not recommended for pumpkin butter or any mashed or pureed pumpkin or winter squash, but we do have directions for canning cubed pumpkin. Pumpkin puree can be frozen or made into a spicy pumpkin leather…
There are not sufficient data available to allow establishing safe processing times for any of these types of products. It is true that previous USDA recommendations had directions for canning mashed winter squash, but USDA withdrew those recommendations…
Some of the factors that are critical to the safety of canned pumpkin products are the viscosity (thickness), the acidity and the water activity. Studies conducted at the University of Minnesota in the 1970's indicated that there was too much variation in viscosity among different batches of prepared pumpkin purees to permit calculation of a single processing recommendation that would cover the potential variation among products (Zottola et. al, 1978). Pumpkin and winter squash are also low-acid foods (pH > 4.6) capable of supporting the growth of Clostridium botulinum bacteria which can cause the very serious illness, botulism, under the right storage conditions. If the bacteria are present and survive processing, and the product has a high enough water activity, they can thrive and produce toxin in the product.
More recent research with pumpkin butter has been done at the University of Missouri. Pumpkin butter is mashed or pureed pumpkin that has had large quantities of sugar added to it, but not always enough to inhibit pathogens. Sometimes an ingredient such as vinegar or lemon juice is added to the formulation to increase the acidity (decrease the pH). However, pumpkin butters produced by home canners and small commercial processors in Missouri have had pH values as high as 5.4. In fact, the pH values seemed to be extremely variable between batches made by the same formulation (Holt, 1995).
It is not possible at this point to evaluate a recipe for pumpkin or mashed squash for canning potential by looking at it. At this point, research seems to indicate variability of the products is great, and in several ways that raise safety concerns. It is best to freeze pumpkin butters or mashed squash.”
Obviously, pumpkin pie filling is essentially “pureed pumpkin” and similar to pumpkin butter. This means that neither the cooked pumpkin puree not the pumpkin pie filling (puree plus sugar and spices) would be candidates for safe home canning.
The University of Illinois Extension also says: “Canning pumpkin butter not a good idea, but try pieces or freezing. “
The University of Minnesota's extension service in October 2009, says: "Canning is not recommended for pumpkin butter or mashed/pureed pumpkin or winter squash. The density of the product prevents adequate heat transfer to the center of the jar and might allow harmful bacteria to survive."
Further questions asked:
The next questions asked are:
- "Well, it's sold in stores and some farms sell
pumpkin butter or canned pumpkin puree, so obviously it must be safe!
Why can't I do it at home in my pressure canner?"
Simple. Is your pressure canner 10 ft tall and reaches pressures of 2 atmospheres or greater like commercial canning equipment? Hmmm, I don't think so!
- Why can't I just add some lemon juice to acidify it?
Sigh. You're just not listening, are you? How much would be the right amount to add? How long would you process it? In a water bath or pressure canner? What pressure? Do you have a lab with an autoclave, incubator and a high quality optical or scanning electron microscope so you can culture it and test for pathogens, and repeat the test a statically relevant number of times to ensure safe reproducibility? Not to mention that adding lemon juice (or vinegar) would not overcome the density/heat penetration issue?
What's that? You were planning to just give it to your friends and family and see if it made them sick? Great. Just great. Did you also forget that botulism is odorless, tasteless and leaves no visible signs of contamination?
The bottom line
The USDA and major universities say they have not yet find a set of home canning conditions that produce a reliably safe pumpkin puree or pumpkin butter. There may be a way to safely do it, but in their tests, they still find active botulism spores.
We hear about cases of fatal food poisoning every year: Taco Bell (E. Coli in undercooked hamburger); Tainted peanut butter, and spinach in 2009, 4 million eggs recalled for Salmonella in 2010 and so on. Cases of fatal or serious food poisoning from home cooking or canning rarely makes the news because it only affects one family and often the cause remains undiagnosed until much later.
Home food canning is perfectly safe, as long as you follow the lab-tested, approved recipes and directions, which presently do not include pumpkin butter. I'm going to wait until the food scientists tell me they have a recipe that can be shown to be safe. My family means more to me than a jar of pumpkin butter.
Questions and comments
- Q. A visitor writes on October 16, 2015: "Hi, I am
wondering if it's safe to make pumpkin butter from store bought
canned pumpkin puree and can it for Christmas gifts. I understand you
can't can fresh pumpkin unless it's cubed, but if I'm using already
canned pumpkin puree is there a safety issue? Thank you. "
A. Sure, you can make pumpkin butter from canned pumpkin, and then you can freeze it or store it in the refrigerator.… but you cannot make CANNED pumpkin butter from canned pumpkin. Once you open the can, it is no longer sterile, is exposed to airborne botulism spores and cannot be made safe using ANY home canning method. So say the food scientists who have repeatedly tested it.
- Canning Pumpkin Butter and Mashed or Pureed Squashes: http://www.uga.edu/nchfp/publications/uga/pumpkin_butter.html
- Extension Service, USDA. 1994. Complete Guide to Home Canning. AIB No. 539. U.S. Department of Agriculture, Washington, DC.
- Holt, D. September 22, 1995. Re: Pumpkin butter. Email message to email@example.com.
- Zottola, E. A., Wolf, I.D., Norsiden, K.L. and D.R. Thompson. 1978. Home canning of food: Evaluation of current recommended methods. Jn. of Food Science 43:1731.
- University of Minnesota's extension service, http://www.extension.umn.edu/foodsafety/components/pdfs/food_preservation_newsletter_october_2009.pdf
- University of Georgia, http://www.uga.edu/nchfp/publications/uga/uga_can_pump.pdf
Can't find the equipment? We ship to all 50 states! Just email us!
This page was updated on 24-Nov-2015
Remember to ALWAYS call the farm or orchard BEFORE you go - weather, heavy picking and business conditions can always affect their hours and crops!
Our other free, informative sites you may like:
EHSO.com - Environmental health and safety information and guidance for the home
ConsumerFraudReporting.org - Information about identity theft, frauds and scams; how to report them and how to protect your identity.
FitnessAndHealthScience.org - Practical fitness, health and diet information that works.
And our other related websites!
Care to Donate to help me keep the website going? Donate to me at Benevia here:
feedback form for questions,
comments and feedback about farms -
Use this form suggest a farm to add to
Or as a last result (I reply to the forms FIRST),write me at
Permission is given to link to any page on www.pickyourown.org Do NOT copy and republish this page in whole or part, that is a copyright violation which will be prosecuted: link to the page instead!
Looking for jobs on farms?